Airline Tubing
Planted Tank Forums
Your Tanks Image Hosting *Tank Tracker * Plant Profiles Fish Profiles Planted Tank Guide Photo Gallery Articles

Go Back   The Planted Tank Forum > Specific Aspects of a Planted Tank > Equipment

Thread Tools Display Modes
Old 01-15-2012, 08:26 AM   #1
Algae Grower
PTrader: (2/100%)
Join Date: Jan 2010
Location: Fort Worth, TX
Posts: 117

Airline Tubing

Okay, so I have been doing some research on CO2 tubing and I have a couple of questions.

I have been using standard clear airline tubing from Walmart for the past year. I was reading and I heard that there is CO2 resistant tubing and that standard airline tubing would leak CO2. So I went out to Home Depot today and bought to different kinds of tubing. I bought one type of tubing labeled as Polyethylene and the other labeled as Vinyl. So my questions are as follows.

(Using the following link as reference: Source)

1. Is vinyl tubing the same as pvc tubing?
2. What material/s is the clear airline tubing made out of?
3. Has anyone here used either the types of tubing I've mentioned or any others? (What are your results?)
chumblaka is offline   Reply With Quote Quick reply to this message
Sponsored Links
Old 01-15-2012, 11:07 AM   #2
Planted Tank Guru
DarkCobra's Avatar
PTrader: (5/100%)
Join Date: Jun 2004
Location: Baton Rouge, LA
Posts: 3,349

Common clear airline tubing is vinyl. Over many years, it gets brittle, and can crack and leak. This accelerates where both CO2 and water or moist air meet, because they combine to form carbonic acid, which attacks the vinyl. If you use this, you may find it needs replacement every year or so. Maybe more, maybe less, all depends on the specifics of the setup.

Many LFS also sell silicone tubing, which is typically a translucent blue. This doesn't get brittle or need replacement, but leaks 55x more CO2 than vinyl tubing. What gets left out of this oft-repeated fact, is that 55x an incredibly small amount is still a very small amount. So small the loss is inconsequential unless you're running a line clear across your home. I recall an experiment where someone attempted to put the leakage to use as as a diffuser, by putting a whole roll of it in their tank; and it didn't leak enough CO2 to make a measurable change in the pH. I typically use this for DIY CO2, because it's relatively cheap, and readily available. I don't recommend it for pressurized, since it's a little too flexible; under the pressures involved it can easily pop off fittings, and might even balloon.

Some folks claim the exact opposite, that silicone gets brittle and vinyl does not, when exposed to CO2. Or even that both get brittle. It's possible some have had these results. But they don't match my own results, or the majority of reports I've seen.

CO2 resistant tubing can be any number of things, but the tubing I received from two different sellers appears to be flexible PVC. Although this is polyvinyl chloride, it's not the same as plain vinyl, and won't get brittle. I hear polyethylene works too, it's just rather stiff by comparison. But again, there's all sorts of conflicting info out there. So for pressurized systems, I just order CO2 resistant tubing from reputable dealers. Not a place to cut corners or deal with uncertainties, in my opinion.
DarkCobra is offline   Reply With Quote Quick reply to this message
Old 01-15-2012, 12:40 PM   #3
Wannabe Guru
PTrader: (0/0%)
Join Date: Jul 2010
Location: Outside Philadelphia, PA
Posts: 1,031

The other factor is that typical aquarium airline is very inexpensive, so if it does get brittle or have other problems, it's easily replaced. True CO2 resistant tubing is nice, but it's a lot more expensive, and as pointed out by DarkCobra, not really needed.
DaveK is offline   Reply With Quote Quick reply to this message

Quick Reply

Register Now

In order to be able to post messages on the The Planted Tank Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:
Your Location. As precise as you feel comfortable with.
Security Question
While balancing on a piece of wood, two inches by four inches known as a 2x4, John and his friend Sally both spotted a dalmatian inside of a truck with sirens. The animal with John and Sally is a _ _ _?
Please select your insurance company (Optional)


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

All times are GMT. The time now is 03:01 PM.

Powered by vBulletin®
Copyright ©2000 - 2015, Jelsoft Enterprises Ltd.
Copyright Planted Tank LLC 2012